Product ID:DENATURED ALCOHOL
MSDS Date:05/08/1989
FSC:6810
NIIN:00-201-0907
MSDS Number: BTKPM

STARTEX CHEMICAL INC.

CONROE, TX 77305
US

Emergency Phone: 409-539-6244

Info Phone: 409-539-6244

Cage: OYFV5

STARTEX CHEMICAL INC

3087 CONROE, TX 77305 US

Telephone: 800-424-9300(CHEMTREC)/936-539-6244

Cage: OYFV5

ETHYL ALCOHOL (ETHANOL)

CAS: 64-17-5

RTECS: KQ6300000

Fraction By Weight: 89%

OSHA PEL 1000 PPM

ACGIH TLV: 1000 PPM; 9394

ETHYL ACETATE (SARA III)

CAS: 141-78-6

RTECS: AH5425000

Fraction By Weight: 5%

OSHA PEL 400 PPM

ACGIH TLV: 400 PPM; 9394

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

METHYL ALCOHOL (METHANOL) (SARA III)

CAS: 67-56-1

RTECS: PC1400000

Fraction By Weight: 4%

OSHA PEL S, 200 PPM

ACGIH TLV: S,200PPM/250STEL; 94

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

N-HEPTANE

CAS: 142-82-5

RTECS: MI7700000

Fraction By Weight: 10%

OSHA PEL 500 PPM

ACGIH TLV: 400 PPM/500STEL;9394

METHYL ISOBUTYL KETONE (SARA III)

CAS: 108-10-1

RTECS: SA9275000

Fraction By Weight: 10%

OSHA PEL 100 PPM

ACGIH TLV: 50 PPM/75 STEL; 9394

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:INHALED:HIGH VAPOR CONCENTRATIONS MAY
CAUSE UPPER RESPIRATROYIRRITATION AND NARCOSIS (SLEEPINESS,
DIZZINESS). EYE:LIQUID & VAPOR CAUSE IRRITATION. SKIN:LOW HAZARD
FOR USUAL INDUSTRIAL HANDLING.
Explanation of Carcinogenicity:HMIS:THIS PRODUCT CONTAINS NO INGREDIENT
AT 0.1% OR GREATER THAT IS LISTED BY IARC, NTP OR OSHA AS A
CARCINOGEN.
Effects of Overexposure:INHALED:HIGH VAPOR CONCENTRATIONS MAY CAUSE
UPPER RESPIRATROYIRRITATION AND NARCOSIS (SLEEPINESS, DIZZINESS).
EYE:LIQUID & VAPOR CAUSE IRRITATION. SKIN:LOW HAZARD FOR USUAL
INDUSTRIAL HANDLING.
Medical Cond Aggravated by Exposure:NO INFORMATION GIVEN ON MSDS BY
MFR.

First Aid:INHALED:REMOVE TO FRESH AIR. TREAT SYMPTOMATICALLY. IF
BREATHING IS DIFFICULT GIVE OXYGEN. GET MEDICAL ATTENTION IF
SYMPTOMS PERSIST. EYE:IMMEDIATELY FLUSH W/PLENTY OF WATER FOR AT
LEAST 15 MINUTES AN D GET MEDICAL ATTENTION IF SYMPTOMS AREPRESENT
AFTER WASHING.

Flash Point Method:TCC
Flash Point:=13.3C, 56.F
Lower Limits:3.53
Upper Limits:21.2
Extinguishing Media:USE WATER SPRAY, CARBON DIOXIDE, ALCOHOL FOAM, OR
DRY CHEMICAL.
Fire Fighting Procedures:WEAR SCBA AND PROTECTIVE CLOTHING TO PREVENT
CONTACT W/SKIN & EYES. WATER MAY BE INEFFECTIVE. USE WATER SPRAY TO
COOL FIRE EXPOSED CONTAINERS.
Unusual Fire/Explosion Hazard:FLAMMABLE LIQUID & VAPOR. VAPORS ARE
HEAVIER THAN AIR AND MAY TRAVEL ALONG GROUND OR FLOOR, THEN 'FLASH
BACK' FROM A DISTANT IGNITION SOURCE.

Spill Release Procedures:ELIMINATE IGNITION SOURCES. SMALL SPILLS MAY
BE COLLECTED USING ABSORBENT MATERIALS. USE WATER SPRAY TO DISPERSE
VAPORS AND DILUTE TO A NON-FLAMMABLE MIXTURE. PREVENT RUNOFF FROM
ENTERING DRAINS, SEWE RS, STREAMS.
Neutralizing Agent:NO INFORMATION GIVEN ON MSDS BY MFR.

Handling and Storage Precautions:FLAMMABLE LIQUID. KEEP AWAY FROM HEAT,
SPARKS & FLAME. KEEP CONTAINER CLOSED. USE W/ADEQUATE VENTILATION.
Other Precautions:COMPLY W/ALL FEDERAL, STATE & LOCAL CODES PERTAINING
TO STORAGE, HANDLING, DISPENSING & DISPOSING OF FLAMMABLE LIQUIDS.
'EMPTY' CONTAINERS MAY CONTAIN RESIDUE OR VAPORS. TREAT THEM WITH
ALL THE PRECA UTIONS DUE FULL ONES.

Respiratory Protection:AN APPROPRIATE NIOSH APPROVED RESPIRATOR FOR
ORGANIC VAPOR MUST BE WORN IF EXPOSURE WILL LIKELY EXCEED
RECOMMENDED LIMITS. IF RESPIRATORS ARE USED A PROGRAM SHOULD BE
ESTABLISHED TO ASSURE COMPLIANCE W/OSHA STANDARD 29CFR1910.134.
Ventilation:GOOD GENERAL VENTILATION (TYPICALLY 10 AIR CHANGES PER
HOUR) SHOULD BE USED. VENTILATION RATES SHOULD MATCH CONDITIONS.
Protective Gloves:IMPERVIOUS
Eye Protection:SAFETY GLASSES W/SIDE SHIELDS OR GOGGLES
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER.
Work Hygienic Practices:MFR: ? HMIS:USE GOOD CHEMICAL HYGIENE
PRACTICE. AVOID UNNECESSARY CONTACT. WASH THOROUGHLY BEFORE EATING
OR DRINKING.
Supplemental Safety and Health
LOCAL EXHAUST VENTILATION OR AN ENCLOSED HANDLING SYSTEM MAY BE NEEDED
TO CONTROL AIRBORNE LEVELS BELOW RECOMMENDED EXPOSURE LIMITS.

HCC:F5
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:=77.8C, 172.F
Vapor Pres:40 MM
Vapor Density:1.59
Spec Gravity:0.79
Solubility in Water:APPRECIABLE
Appearance and Odor:CLEAR LIQUID, ALCOHOL ODOR
Percent Volatiles by Volume:100

Stability Indicator/Materials to Avoid:YES
OXIDIZING MATERIALS MEY CAUSE A VIGOROUS REACTION.
Stability Condition to Avoid:NO INFORMATION GIVEN ON MSDS BY MFR.
Hazardous Decomposition Products:AS W/ANY THER ORGANIC MATERIAL,
COMBUSTION WILL PRODUCE CARBON DIOXIDE AND PROBABLY CARBON
MONOXIDE.
Conditions to Avoid Polymerization:WILL NOT OCCUR

Waste Disposal Methods:MIX WITH COMPATIBLE CHEMICAL WHICH IS LESS
FLAMMABLE AND INCINERATE. OBSERVE ALL FEDERAL, STATE AND LOCAL LAWS
CONCERNING HEALTH AND ENVIRONMENT.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.